- Open Access
Effective pulmonary delivery of an aerosolized plasmid DNA vaccine via surface acoustic wave nebulization
Respiratory Research volume 15, Article number: 60 (2014)
Pulmonary-delivered gene therapy promises to mitigate vaccine safety issues and reduce the need for needles and skilled personnel to use them. While plasmid DNA (pDNA) offers a rapid route to vaccine production without side effects or reliance on cold chain storage, its delivery to the lung has proved challenging. Conventional methods, including jet and ultrasonic nebulizers, fail to deliver large biomolecules like pDNA intact due to the shear and cavitational stresses present during nebulization.
In vitro structural analysis followed by in vivo protein expression studies served in assessing the integrity of the pDNA subjected to surface acoustic wave (SAW) nebulisation. In vivo immunization trials were then carried out in rats using SAW nebulized pDNA (influenza A, human hemagglutinin H1N1) condensate delivered via intratracheal instillation. Finally, in vivo pulmonary vaccinations using pDNA for influenza was nebulized and delivered via a respirator to sheep.
The SAW nebulizer was effective at generating pDNA aerosols with sizes optimal for deep lung delivery. Successful gene expression was observed in mouse lung epithelial cells, when SAW-nebulized pDNA was delivered to male Swiss mice via intratracheal instillation. Effective systemic and mucosal antibody responses were found in rats via post-nebulized, condensed fluid instillation. Significantly, we demonstrated the suitability of the SAW nebulizer to administer unprotected pDNA encoding an influenza A virus surface glycoprotein to respirated sheep via aerosolized inhalation.
Given the difficulty of inducing functional antibody responses for DNA vaccination in large animals, we report here the first instance of successful aerosolized inhalation delivery of a pDNA vaccine in a large animal model relevant to human lung development, structure, physiology, and disease, using a novel, low-power (<1 W) surface acoustic wave (SAW) hand-held nebulizer to produce droplets of pDNA with a size range suitable for delivery to the lower respiratory airways.
The lung is an attractive site for delivery of gene therapy and DNA vaccine agents since it is accessible, has a large surface area and is highly cellular and vascularized to facilitate transfection. Further, pulmonary delivery via inhalation is non-invasive and allows for pain-free access where potential systemic side effects are minimized [1, 2]. Replacement of the parenteral route with alternative modes of administration would mitigate vaccine safety issues and the requirement for skilled personnel, amongst the many other issues associated with injections [3, 4]. Indeed, there has been significant interest to date in the potential of pulmonary gene therapy in treating pulmonary diseases caused by single gene mutation such as cystic fibrosis and 1-antitrypsin deficiency . Further, there is potential for pulmonary vaccination to be useful against a range of pathogens, since immunity can be induced at mucosal sites through which these agents enter the body .
Effective pulmonary administration of DNA demonstrating cellular or tissue expression and subsequent induction of protective immunity has been a challenging task. Aerosols containing plasmid DNA (pDNA) can reach and adhere to the bronchial and alveolar epithelial cells only if the aerosol droplets are between 1 and 5 μm, enabling pDNA entry and subsequent gene expression . Recent work nevertheless suggests delivery via the mucosa may be more feasible than once thought .
While nebulizers are the delivery method of choice for macromolecules , delivery of non-complexed pDNA is impractical in current nebulizers due to poor droplet size control as well as the generation of sufficient hydrodynamic stresses that can shear pDNA molecules (>5 kbp) into open circular and fragmented configurations [8–10]. The transfection efficiency of such post-nebulized DNA has been shown to be as low as 10%, which often necessitates complexation of the DNA in an attempt to protect it from shear-induced degradation . For example, the pulmonary delivery of cationic polymers has led to modestly improved gene expression in the airways of sheep [12, 13]. However, not all polyplexes (nor lipoplexes) retain biological efficacy after aerosolization , with some commonly used synthetic polymers such as polyethylenimine (PEI) considered to be cytotoxic . Effective delivery via the pulmonary route therefore requires the aerosolized DNA to be internalized into the target cell via endocytosis, avoiding degradation either during delivery or via exposure to lysosomal or cytoplasmic nucleases, and subsequent transcription and translation to produce the desired gene product .
Surface acoustic wave (SAW) nebulization was recently shown to effectively form aerosols of a short acting β2-agonist with a respirable fraction of >70% , much more than the typical 30–40% lung dose available via current nebulizers . Rayleigh SAWs, transverse-axial polarized electroacoustic waves generated by a sinusoidal electric field between the interlaced fingers of an interdigital transducer (IDT) electrode, are formed and propagate at nanometer amplitudes at MHz to GHz-order frequencies along piezoelectric lithium niobate (LiNbO 3). In such devices, the SAW is localized to the substrate surface, and most of the energy input into the system is near the surface and transferred into fluid resting upon it with minimal loss. As such, SAW nebulization requires only about 1 W of power to operate, significantly less than conventional bulk piezoelectric ultrasonic radiators, and convenient for use in handheld devices .
The aim of this study was to demonstrate the feasibility of SAW nebulization as an aerosol delivery platform for DNA delivery to the lungs in a large animal model.
Preparation of pDNA
The mouse malaria P. yoelli merozoite surface protein 4/5 (PyMSP4/5) was cloned into the mammalian expression vector pVR1020 and was used throughout the in vitro work . The VR1020 plasmid encoding yellow florescent protein (YFP) that replaced the PyMSP4/5 gene was used for the in vivo studies to aid visualization of the gene expression. For the immunization trial, a plasmid DNA was prepared from a gene encoding an influenza A virus surface hemagglutinin protein, human hemagglutinin (A/Solomon Islands/3/2006 (egg passage) (H1N1) strain), once cloned into the mammalian expression vector pVR1020 (Vical Inc., USA). The entire coding sequence of HA was amplified by PCR using primers forward and reverse that incorporated a BamHI site at the 5’ end and a EcoRI site at the 3’ end, forward: 5’-CGCGGATCCATGAAAGTAAAACTACTGGTCCTGTTATG-3’; reverse: 5’-CCGGAATTCTTGTTTGTAATCCCATTAATGGCATTTTGT-3’. The PCR product was digested with BamHI/EcoRI and ligated into the vector, pVR1020, resulting the in plasmid pVR1020–HA.
A colony of E. coli DH5 α harboring either plasmid pVR1020–PyMSP4/5 (∼5.6 kbp), pVR1020–YFP (∼5.7 kbp) or pVR1020–HA (∼6 kbp) was picked from a streaked selective plate and inoculated in 10 ml of LB medium containing 100.0 μg/ml of kanamycin. The starter culture was incubated at 37°C and agitated at 200 rpm for 8 h before being transferred to five separated 200 ml LB media, and further cultured for 12 h. The cell cultures were stored at -70°C for subsequent use. The plasmids were purified from cells using an endotoxin-free plasmid purification kit (QIAGEN Mega, Australia) according to the manufacturer’s instructions.
SAW nebulization of Plasmid DNA
Different concentrations of pDNA solution (5–85 μg/ml in deionized water for pVR1020–PyMSP4/5 and 1.5 mg/ml in 0.9% NaCl for pVR1020–YFP) were nebulized using both 20 and 30 MHz SAW devices at approximately 110 μ ℓ/min and carefully collected in microcentrifuge tubes for further analysis as illustrated in Figure 1. The concentration of pDNA in the collected samples was determined by a UV spectrophotometer (NanoDrop 1000, Thermo Scientific, USA) at a wavelength of 260 nm. The purity of pDNA samples was assessed by the samples’ absorbance at 260 and 280 nm.
Agarose gel electrophoresis
Both control and nebulized pDNA samples were analyzed for potential alterations in the plasmid structure with 0.8% agarose gel electrophoresis that used a 1 kbp DNA ladder and ethidium bromide (EtBr) staining . The gel was made up of 0.8 g agarose at 50 × dilution of TAE buffer (242.0 g Tris base, 57.1 ml CH3COOH, 9.3 g of EDTA). The gel was stained with 3 μg/ml EtBr and the electrophoresis was carried out under 60 V for 90 min. The resulting gel was analyzed and imaged in a Molecular Imager Gel Doc XR system (Bio-Rad, Australia). The intensity of the bands for each structure corresponds to the number of DNA molecules. The percentage of supercoiled (SC) and open circular (OC) to degraded linear pDNA was quantified via densitometry software (Quantity One, Bio-Rad, Australia) by comparing pre- and post-nebulized samples. However, it was found that the binding of EtBr to different plasmid structures is dependent on the DNA topology, and a correction factor of 1.36 was therefore multiplied against the measured fluorescence values of the supercoiled structure .
AFM imaging of pDNA
A freshly cleaved 10 mm diameter mica disc was coated with 10 μl of 10 mM Ni(NO 3) 2 to render the mica surface cationic for adsorption of anionic pDNA. Ten μl of pDNA solution (6–25 μg/ml) was pipetted onto the mica surface. Two to five minutes were allowed to elapse to enable the pDNA to absorb onto the surface, after which the mica disc was rinsed with ultra-pure water and dried under a gentle stream of N 2 gas prior to AFM imaging. The surface morphology of pDNA was imaged with an Ntegra Scanning Probe Laboratory (NT–MDT, Zelenograd, Russia) operating in intermittent contact (or tapping) mode in air using MikroMasch NSC15 probes . Images of 512 × 512 pixels with a scan size of 3 × 3, 1 × 1 and 0.5 × 0.5 μm2 were acquired at scan rates of 1–2 Hz. AFM images were processed to correct plane tilt, arcing and line fluctuations. For the presented images, 3 × 3 Gaussian noise filtering and 3D rendering was also applied using WsXM freeware (version 5, build 1.1, Nanotec Electronica S.L., Spain).
De Brouckere (volume moment, D43) mean diameter is the average particle size relevant to the dose’s delivery efficiency when the particles are droplets of unit density. To examine the aerosol size distribution of the nebulized pDNA, pVR1020–PyMSP4/5 was prepared in glycerol and the aerosol size for different preparations was characterized by laser diffraction (Spraytec, Malvern Instruments, UK) following nebulization using the SAW device. In order to characterize the pDNA aerosol size distribution, D43 was recorded during the measurements.
For gene expression detection studies, male Swiss mice (8–10 week old) were used, weighing 37–40 g, and for the genetic immunization trial via intratracheal instillation, female Sprague-Dawley rats (8–10 week old), weighing 241–270 g, were purchased from Animal Resources Centre (Canning Vale, Australia). Mice and rats were housed under specific pathogen-free conditions at the Monash Institute of Pharmaceutical Sciences animal facility (Parkville, Australia) and had access to food and water ad libitum.
For the DNA vaccination of sheep via inhalation, female Merino-cross ewe lambs (5-6 months of age) used in these studies were housed in pens (Department of Physiology animal facility, Clayton, Australia) and fed ad libitum and judged free of significant pulmonary disease on the basis of clinical examination. All experimental animal procedures were approved by the Animal Experimentation Ethics Committee of Monash University, following guidelines set by the National Health and Medical Research Council (NHMRC) of Australia.
Gene expression in vivofollowing intratracheal plasmid DNA delivery in mice
For in vivo transfection, the mice were anesthetized by intraperitoneal injection of 100 mg/kg body weight of ketamine (Parnell Laboratories, Australia) and 10 mg/kg body weight of xylazine (Tony Laboratories, Australia). A solution of sterile pVR1020 encoding YFP in 0.9% NaCl at a concentration of 1.5 mg/ml was nebulized using a 30 MHz SAW nebulizer and the condensed aerosol containing the nebulized plasmid was carefully collected as described earlier. For intratracheal instillation, the mice were suspended at 45 degrees by the upper teeth on a rodent dosing board and the trachea was visualized using a fiber optic stylet connected to an endotracheal tube (Biolite small animal intubation system, Kent Scientific Corp, USA). The trachea was intubated and post-nebulized plasmid in saline (50 μl) was delivered followed by 200 μl of air. The mice were sacrificed 24 hours later, and their lungs were harvested and subsequently frozen in Jung tissue freezing medium (Leica Microsystems, Germany) for later analysis of tissue sections. Cryosections (10 μm) cut onto glass microscope slides were fixed with 1% paraformaldehyde, mounted with mowiol (4–88 Reagent from Calbiochem, Australia) solution to which 4’,6-diamidino–2–phenylindole dilactate (DAPI, dilactate) was added, and subsequently examined under a confocal laser scanning microscope (A1, Nikon Instruments Inc., Japan) for YFP gene expression. Lung and airway morphology was examined on adjacent sections with hematoxylin and eosin. As additional confirmation for the detection of YFP in the mice lungs, the lung samples were homogenized using lysis buffer containing 50 mM Tris (pH 7.5), 100 mM NaCl and 1% Triton X–100. The homogenate was then centrifuged and the supernatant was used for Western blot detection  of the YFP protein where SDS-PAGE and immunoblotting analysis procedures were carried out as previously described, except that the membranes were probed with rabbit anti-YFP antisera.
Pulmonary intratracheal vaccinations using pre-SAW nebulized plasmid DNA in rats
For pulmonary vaccinations, solution of sterile pVR1020 encoding HA in 5% dextrose at a concentration of 300 μg/ml was nebulized at approximately 110 μl/min using a 30 MHz device and the condensed aerosol containing the nebulized plasmid was carefully collected as described earlier. Rat immunizations were carried out using the intratracheal instillation technique also described earlier where the trachea of the rats were intubated and 300 μg of post-nebulized plasmid in 5% dextrose (n = 8, post-nebulized group), 300 μg of pre-nebulized plasmid in 5% dextrose (n = 8, pre-nebulized group), and 5% dextrose (n = 8, naïve group) in a total volume of 100 μl was delivered followed by 200 μl of air. Subsequent immunizations were carried out 2 weeks (secondary) and 3 weeks (tertiary) after the primary immunization. Serum was collected prior to the commencement of the study and 5 weeks after the first immunization. Blood was collected from the tail vein, then left to coagulate for the collection of sera and stored at -20°C until further analyzed.
Pulmonary DNA inhalation vaccination using SAW nebulization in sheep
Sheep (n=4) were immunized via inhalation through an endotracheal tube inserted through the nostril with sterile pVR1020 encoding HA in 5% dextrose at a concentration of 85 μg/ml, nebulized using a 30 MHz SAW device in a chamber placed in line with the inspiratory limb of the mechanical ventilator (ventilator Model 55-0723; Harvard Apparatus, MA) set at 20 breaths/min at 50% inspiration for 20-30 minutes (as per Figure 2). Two bacterial/viral filters (Hudson RCI, USA) and two low flow resistance, Hudson one-way valves (Hudson RCI, USA) were placed at each end of the inspiratory and expiratory limbs in line with the rest of the connecting tubing. In order to calculate the delivered mass of pDNA to the ovine lung, all tubing, including the filters and valves, were carefully washed with deionized water to recoup any pDNA present, if any, and subsequently quantified via a UV spectrophotometer described earlier. Subsequent immunizations were carried out 3 weeks (secondary) and 6 weeks (tertiary) after the primary immunization. Serum from peripheral blood samples collected prior to the commencement of the study and 1 week after the last immunization were stored frozen prior to determination of hemagglutination inhibition activity.
Evaluation of antibody responses by enzyme-linked immunosorbent assay
For the detection of anti-influenza (HA) antibodies in the serum samples, enzyme-linked immunosorbent assays (ELISAs)  were performed in 96-well MaxiSorp plates (Nunc, Denmark). Plates were coated with 0.05 μg HA protein (Immune Technology Corp., USA) in carbonate coating buffer (0.015 M Na2CO 3, 0.035 M NaHCO 3, 0.003 M NaN 3, pH 9.6) and blocked with 2% w/v skim milk powder. Serial 2-fold dilutions of serum samples were added in duplicate followed by anti-sheep IgG horseradish peroxidase (HRP) conjugated immunoglobulin (DAKO, Denmark) or dilution of anti-sheep IgA horseradish peroxidase (HRP) conjugated immunoglobulin (AbCam, Australia). Plates were developed with 3,3’,5,5’–tetramethylbenzidine (TMB) (Sigma Aldrich, Australia) substrate. Absorbance was measured at 450 nm and endpoint titers were calculated.
Serum evaluation of hemagglutination inhibition activity
The serum samples collected from immunized sheep and rats were tested for inhibition activity against four hemagglutinating units (HAU) of A/Solomon Islands/3/2006 virus in microtiter plates at room temperature using 1% v/v chicken erythrocytes . Virus-induced hemagglutination titers were determined as the minimum dilution of samples required to inhibit hemagglutinating activity of four HAU of virus.
Statistical analyses were performed using SPSS (IBM Corporation, Armonk, USA). One-way ANOVA with a Tukey’s post-hoc test was used for data that survived Shapiro-Wilk’s (SW) normality test with significance p>0.05. In instances where the SW test was significant (p<0.05), the non-parametric Kruskal-Wallis (KW) test was used instead to test for the overall significance between independent groups. Where differences were observed, Mann-Whitney (MW) tests were performed between two independent samples to identify the differences. All data are expressed as the mean ± standard deviation. The results were considered significant if p<0.05.
SAW nebulized pDNA displays aerosol size characteristics to suit deep lung deposition
Our initial investigations sought to determine the aerosol size distribution of the nebulized pDNA (PyMSP4/5), prepared in glycerol, including the desired 1–5 μm range for pulmonary delivery. As seen in Figure 3, the pDNA formulation at 100 μg/ml with glycerol concentrations of 10%, 20% and 40% enabled average droplet size distributions under 5 μm to be reliably achieved. Increasing the concentration of glycerol was seen to reduce the average aerosol diameter for a fixed pDNA concentration (Table 1), thus confirming our ability to establish some control over the desired aerosol dimension through the physical properties of the liquid.
SAW nebulization preserves integrity of pDNA
The structural integrity of pDNA plays a key role in preserving the bio-activity where AFM imaging and agarose gel electrophoresis was used for structural analysis of pDNA encoding PyMSP4/5 before and after SAW nebulization. AFM imaging revealed that the non-nebulized plasmid DNA showed a tightly twisted supercoiled geometry, with few relaxed strands (open circular structures) (Figure 4(a)), characteristic morphologies for uncondensed plasmids . A representative image of the SAW nebulized pDNA showed some aggregated structures and some relaxed open loop structures with little fragmented strands (Figure 4(b)). These structural characteristics were further confirmed upon examination of the pDNA preparations by agarose gel electrophoresis, where changes in the supercoiled, open circular and fragmented pDNA structures prior to and after nebulization were observed (Figure 4(c)). Significantly, the unprotected naked pDNA was preserved during the SAW nebulization process, and in most cases more than 90% of the initial supercoiled pDNA was still present post-nebulization (Figure 4(d)).
Airway administration of nebulized pDNA induces gene expression in the murine lung
Mice were used to assess gene expression following SAW-nebulized airway administration of pDNA encoding yellow fluorescent protein (YFP) (Figure 5(a)-(f)). Scattered, indiscriminate YFP expression was observed in the mouse lung when examined 24 hours following intratracheal instillation with condensed nebulized pVR1020-YFP (Figure 5(c)). Importantly, YFP expression was absent in the untreated mouse lung (Figure 5(f)). YFP-positive cells detected in the mouse lung were mainly located close to the epithelium of the conducting airways, where there appeared to be discrete aggregates of YFP protein (Figure 6(a)-(c)). Further confirmation of YFP expression in the murine lung was demonstrated in Western blot analysis of lung tissue collected 24 hours post-pDNA administration (Figure 6(d)).
No tissue damage was evident in the mouse lungs instilled with SAW-nebulized pDNA (as indicated by the absence of hemosiderin deposits in tissue sections stained with Perl ′s Prussian blue) and was confirmed by the lack of inflammatory cells and lack of micro-haemorrhaging in the lung tissue (data not shown).
Lung pDNA vaccination induces serum antibody responses and HAI activity in rats
Sprague Dawley rats were used as a suitable small animal model for infuenza . To examine antibody responses to pDNA vaccination (pVR1020 encoding HA) via intratracheal instillation in rats, ELISAs were performed on sera collected prior to and two weeks after a third airway immunization. Significant increases in both IgG and IgA antibody titer levels against the influenza virus HA protein were observed in both groups of rats that received pre-nebulized and post-nebulized pDNA vaccinations, compared to the vehicle-only control group (Figure 7, p<0.001). Importantly, no differences in IgG or IgA levels (p>0.05 in both cases) were observed between the groups that received the nebulized and non-nebulized form of the pDNA vaccine.
Antibody responses detected in sera following lung instillation with the pDNA vaccine showed clear functional activity in the hemagglutination inhibition (HAI) assay (Table 2). Both groups that received pDNA vaccine achieved appropriate HAI titers at levels considered to be protective by the World Health Organization (WHO)  in establishing immunity in humans. Compared to the control group, serum from rats immunized with pDNA via intratracheal instillation showed significantly increased HAI activity (p<0.001), with no difference seen between the pre-nebulized and post-nebulized forms of pDNA.
Aerosolized pDNA vaccination induces antibodies in sheep
Sheep were used to assess the efficacy of SAW-nebulized airway administration of pDNA in a large animal model with similar lung physiology to humans . The sheep were administered three airway immunizations at three-week intervals using a 30 MHz SAW device, nebulizing the pDNA solution at approximately 110 μ ℓ/min. The average dose of pDNA delivered to the airways was 156 ±44 μg (mean ± S.D.; data not shown). SAW-nebulized pDNA delivered to the sheep airways induced significant HAI activity, with a mean HAI titer of 192 ±74 (n=4), in sera collected one week after the third immunization (Table 3), and was comparable to the outcome observed in rats (see Table 2).
In this study, we demonstrate the use of a SAW nebulization device for the generation of aerosolized pDNA with suitable size and stability characteristics to facilitate effective pulmonary delivery particularly for influenza vaccination. The in vivo studies conducted showed for the first time, successful delivery of the SAW-generated pDNA to the airways of mice, rats, and importantly, in a large animal model (sheep).
Generation of SAW nebulized droplets effective for deep lung deposition
The generation of aqueous pDNA aerosol droplets with sizes smaller than the 5 μm diameter required for optimal deposition in the deep lung region  is particularly difficult due to the high surface tension of water . The nebulized droplet size is independent of excitation frequency, but strongly dependent on fluid characteristics to provide a route to effectively tune droplet size . During SAW nebulization, the droplet size formed from the device is governed by the wavelength of the capillary waves generated on the surface of the source drop . The wavelength in turn, is predicted by the balance between the capillary and viscous forces that dominate at the surface such that the droplet diameter could be lowered by increasing the surface tension and dynamic viscosity of the source drop . In the present study, glycerol, known to be safe in aerosol form , was introduced to modify the viscosity. The concentration of the pDNA had a minor effect on the droplet diameter that can be addressed by changing the glycerol concentration. By employing 20% glycerol in the pDNA stock solution, the SAW nebulizer delivered droplets with a mean diameter less than 5 μm, which is required for effective deep lung deposition.
SAW nebulization preserves the DNA integrity
Compact supercoiled DNA is the most immunogenic form and, according to FDA requirements, must be present at >80% in a licensable vaccine [33, 34]. The SAW nebulization process is verified in this study to preserve the DNA integrity, where more than 90% of the initial supercoiled pDNA was still present after SAW nebulization. Scission of one of the two strands of the pDNA releases torsional energy stored in the supercoiled plasmid, and causing it to relax into an open circular form, while scission of both strands resuls in a linear polynucleotide and subsequent DNA fragments . AFM and ethidium bromide agarose gel electrophoresis of the pDNA (pVR1020–PyMSP4/5) before and after SAW nebulization showed that the tightly twisted supercoiled geometry of the pDNA was effectively maintained. The AFM images nevertheless showed some morphological differences between the non-nebulized and SAW-nebulized pDNA, where the later showed aggregated structures commonly induced during nebulization processes , presumed to be tightly twisted strands of pDNA. The frequency of the SAW nebulizer had little effect on the results, and likewise, pDNA concentrations in the source drop prior to nebulization (5 to 85 μg/ml) had minimal effect on the percentage of supercoiled pDNA left after nebulization.
A small proportion of the pDNA prior to SAW nebulization was found to be fragmented, most likely occurring during plasmid purification and preparation. This was especially evident at a pDNA concentration of 5 μg/ml, with around 50% and 20% of supercoiled and fragmented pDNA, respectively. Linear, double-stranded DNA is very susceptible to flow-induced stresses. For example, minor differences in their characteristic dimension that arise from scission have large effects on their response to hydrodynamic stresses . Stretching hydrodynamic forces of only 0.3 nN, well below the 1.6–5.0 nN required to break the covalent bonds within, are known to cause irreversible strand separation and formation of nicks, degrading the pDNA . Though cavitation is absent in SAW nebulization , accelerations in the fluid of 10 7–10 8 m/s 2 are typically due to the MHz-order frequencies used. If the relaxed forms of the pDNA are adjacent to the fluid interface, it is possible that the gradient in the acceleration and consequently the shear stress across the pDNA molecules is sufficient to cause further damage, though the relaxation time scale of the fluid shear, ∼10 ns, is two orders of magnitude smaller than that required to shear large molecules, suggesting the risk of denaturing molecules such as DNA  is negligible. Compared to standard ultrasonic nebulization at 20–80 kHz, where cavitation is prevalent and large molecules like pDNA in solution actually serve as cavitation bubble nucleation sites  and cause wholesale destruction of such molecules, the damage caused by SAW nebulization is minor. For 5 kbp plasmids, the percentage of fragmented pDNA after nebulization is lower with SAW (<20%) than with conventional (>35%) or vibrating mesh nebulizers (>40%) . Hence, the SAW nebulization approach has several key advantages over the current generation of ultrasonic medical nebulizers for the delivery of large molecules .
We set out to test the capacity of nebulized DNA to induce immune responses in-vivo. Previous studies using small animal models to investigate aerosol delivery of pDNA formulations have found it difficult to effectively control the delivered dose via nebulization . Hence preliminary experiments in these animals involved recovery of the nebulized material followed by intratracheal instillation of the condensate. When post-nebulized pVR1020–YFP plasmid was introduced into the lungs of mice, the expression of yellow fluorescent protein (YFP) provided evidence of transfection that was entirely absent in the lungs of untreated mice. We hypothesize that the expression of YFP which appears as discrete aggregates with granular appearance was presumably close to the epithelium of the conducting airways, consistent with gene expression patterns following DNA vaccination in mouse lungs in another study . Furthermore, Western blot analysis confirmed the presence of the YFP only in the lungs of treated lungs.
SAW nebulized DNA induces protective antibodies after pulmonary delivery
More importantly, our data showed that SAW nebulization did not inhibit the ability of the vaccine to induce protective antibodies. Anti-HA antibody titers detected here were found to be comparable to the vaccination outcomes using a similar pDNA influenza vaccine complexed with polyethyleimine (PEI) . Our results suggest that naked pDNA can be effectively delivered to the lung with subsequent transfection into airway cells (despite likely degradation of the pDNA) while also demonstrating preserved immunogenicity of the DNA vaccine subjected to the SAW nebulization process.
Following pDNA vaccination in rats, serum hemagglutination inhibition (HAI) titers were significantly greater than 40, levels considered to be protective according to WHO standards  and indicative of what would translate into a significant humoral response elicited to administered pDNA. These results are particularly encouraging when compared elsewhere to the outcome of vaccination with pDNA encoding swine H1N1 complexed with PEI and administered intranasally to BALB/c mice . Although low doses of pDNA were used in this study, some synthetic adjuvants such as PEI are known to be highly cytotoxic , and are likely to encounter problems with approval for human use. Our results in sheep also compare well to the administration of HA protein in sheep via subcutaneous injection and via intratracheal instillation to the lung that resulted in HAI titers of 95 to 122 .
Translation of successful outcomes with DNA vaccination seen in small (rodent) to larger animal models  including humans  continues to represent a major hurdle in this emerging field. The similarities in size, structure and physiology of sheep and human lungs  suggests that sheep could be used as a relevant large animal model to test the efficacy of pulmonary DNA vaccination for human applications. In the present study, the SAW nebulized pDNA induced a robust antibody response when delivered into the lungs of conscious sheep under mechanical respiration, with similar levels in antibody response to that observed in rats. Given the scope of the current study, we have not included the impactor measurement data. However, the sheep aerosol study confirms that the aerosols generated by SAW were indeed suited for deep lung delivery (droplet size range 0.5-5 μm), evidenced by the HAI assays and the induction of the functional antibodies.
This study reports the first instance of successful pDNA delivery via inhalation using an unprotected pDNA vaccine in a clinically relevant large animal model. Due to similarities with humans in lung structure and physiology, sheep provide a better preclinical model than smaller animals for the optimization of nebulizers intended for lung gene delivery. Studies presented here and elsewhere indicate that sheep are proving to be an invaluable model for the assessment of gene therapy efficacy, the delivery profile of the nebulizer to suit conventional sized devices and the safety of the gene transfer protocol, all critically relevant endpoint measurements . Further, the present findings suggest that the SAW nebulizer may serve to effectively deliver pDNA vaccines that can be rapidly produced upon demand. This represents a significant outcome in the context of ensuring a timely response to pandemic disease outbreaks, and in the developing world where there is neither a sufficient health workforce nor access to safe injection methods.
Forde GM: Rapid-response vaccines-does DNA offer a solution?. Nat Biotechnol. 2005, 23 (9): 1059-1062. 10.1038/nbt0905-1059.
Birchall J: Pulmonary delivery of nucleic acids. Expert Opin Drug Deliv. 2007, 4 (6): 575-578. 10.1517/17425247.4.6.575.
Giudice EL, Campbell JD: Needle-free vaccine delivery. Adv Drug Deliv Rev. 2006, 58 (1): 68-89. 10.1016/j.addr.2005.12.003.
Simonsen L, Kane A, Lloyd J, Zaffran M, Kane M: Unsafe injections in the developing world and transmission of bloodborne pathogens: a review. Bull World Health Organ. 1999, 77 (10): 789-800.
West J, Rodman DM: Gene therapy for pulmonary diseases. Chest. 2001, 119 (2): 613-617. 10.1378/chest.119.2.613.
Lu D, Hickey AJ: Pulmonary vaccine delivery. Expert Rev Vaccines. 2007, 6 (2): 213-226. 10.1586/147605184.108.40.206.
Ye L, Zeng R, Bai Y, Roopenian D. C, Zhu X: Efficient mucosal vaccination mediated by the neonatal Fc receptor. Nat Biotechnol. 2011, 29 (2): 158-163. 10.1038/nbt.1742.
Catanese D, Fogg J, Schrock D, Gilbert B, Zechiedrich L: Supercoiled minivector DNA resists shear forces associated with gene therapy delivery resists shear forces associated with gene therapy delivery. Gene Ther. 2011, 19 (1): 94-100.
Arulmuthu ER, Williams DJ, Baldascini H, Versteeg HK, Hoare M: Studies on aerosol delivery of plasmid DNA using a mesh nebulizer. Biotechnol Bioeng. 2007, 98 (5): 939-955. 10.1002/bit.21493.
Lentz Y, Anchordoquy T, Lengsfeld C: DNA acts as a nucleation site for transient cavitation in the ultrasonic nebulizer. J Pharm Sci. 2006, 95 (3): 607-619. 10.1002/jps.20511.
Birchall JC, Kellaway IW, Gumbleton M: Physical stability and in-vitro gene expression efficiency of nebulised lipid-peptide-DNA complexes. Int J Pharm. 2000, 197 (1-2): 221-231. 10.1016/S0378-5173(00)00339-2.
Davies LA, McLachlan G, Sumner-Jones SG, Ferguson D, Baker A, Tennant P, Gordon C, Vrettou C, Baker E, Zhu J, Alton EWFW, Collie DDS, Porteous DJ, Hyde SC, Gill DR: Enhanced lung gene expression after aerosol delivery of concentrated pDNA/PEI complexes. Mol Ther. 2008, 16 (7): 1283-1290. 10.1038/mt.2008.96.
McLachlan G, Baker A, Tennant P, Gordon C, Vrettou C, Renwick L, Blundell R, Cheng SH, Scheule RK, Davies L, Painter H, Coles RL, Lawton AE, Marriott C, Gill DR, Hyde SC, Griesenbach U, Alton EWFW, Boyd AC, Porteous DJ, Collie DDS: Optimizing aerosol gene delivery and expression in the ovine lung. Mol Ther. 2006, 15 (2): 348-354.
Rudolph C, Ortiz A, Schillinger U, Jauernig J, Plank C, Rosenecker J: Methodological optimization of polyethylenimine (PEI)-based gene delivery to the lungs of mice via aerosol application. J Gene Med. 2005, 7 (1): 59-66. 10.1002/jgm.646.
Moghimi SM, Symonds P, Murray JC, Hunter AC, Debska G, Szewczyk A: A two-stage poly (ethylenimine)-mediated cytotoxicity: implications for gene transfer/therapy. Mol Ther. 2005, 11 (6): 990-995. 10.1016/j.ymthe.2005.02.010.
Banks G, Roselli R, Chen R, Giorgio T: A model for the analysis of nonviral gene therapy. Gene Ther. 2003, 10 (20): 1766-1775. 10.1038/sj.gt.3302076.
Qi A, Friend JR, Yeo LY, Morton DAV, McIntosh MP, Spiccia L: Miniature inhalation therapy platform using surface acoustic wave microfluidic atomization. Lab Chip. 2009, 9 (15): 2184-2193. 10.1039/b903575c.
Clay MM, Clarke SW: Wastage of drug from nebulisers: a review. J R Soc Med. 1987, 80 (1): 38-39.
Qi A, Yeo LY, Friend JR: Interfacial destabilization and atomization driven by surface acoustic waves. Phys Fluids. 2008, 20: 074103-10.1063/1.2953537.
Wang L, Kedzierski L, Schofield L, Coppel RL: Influence of glycosylphosphatidylinositol anchorage on the efficacy of DNA vaccines encoding plasmodium yoelii merozoite surface protein 4/5. Vaccine. 2005, 23 (32): 4120-4127. 10.1016/j.vaccine.2005.03.016.
Lentz Y, Worden L, Anchordoquy T, Lengsfeld C: Effect of jet nebulization on DNA: Identifying the dominant degradation mechanism and mitigation methods. J Aerosol Sci. 2005, 36 (8): 973-990. 10.1016/j.jaerosci.2004.11.017.
Projan SJ, Carleton S, Novick RP: Determination of plasmid copy number by fluorescence densitometry. Plasmid. 1983, 9 (2): 182-190. 10.1016/0147-619X(83)90019-7.
Glover DJ, Ng SM, Mechler A, Martin LL, Jans DA: Multifunctional protein nanocarriers for targeted nuclear gene delivery in nondividing cells. FASEB J. 2009, 23 (9): 2996-3006. 10.1096/fj.09-131425.
Korfhagen TR, Bruno MD, Ross GF, Huelsman KM, Ikegami M, Jobe AH, Wert SE, Stripp BR, Morris RE, Glasser SW, Bachurski CJ, Iwamoto HS, Whitsett JA: Altered surfactant function and structure in sp-a gene targeted mice. Proc Natl Acad Sci. 1996, 93 (18): 9594-9599. 10.1073/pnas.93.18.9594.
Haan Ld: Nasal or intramuscular immunization of mice with influenza subunit antigen and the B subunit of Escherichia coli heat-labile toxin induces IgA- or IgG-mediated protective mucosal immunity. Vaccine. 2001, 19 (20-22): 2898-2907. 10.1016/S0264-410X(00)00556-9.
Vujanic A, Snibson KJ, Wee JLK, Edwards SJ, Pearse MJ, Scheerlinck J-PY, Sutton P: Long-term antibody and immune memory response induced by pulmonary delivery of the influenza iscomatrix vaccine. Clin Vaccine Immunol. 2012, 19 (1): 79-83. 10.1128/CVI.05265-11.
Hansma HG: Surface biology of DNA by atomic force microscopy. Annu Rev Phys Chem. 2001, 52: 71-92. 10.1146/annurev.physchem.52.1.71.
Daniels MJ, Selgrade MK, Doerfler D, Gilmour MI: Kinetic profile of influenza virus infection in three rat strains. Comp Med. 2003, 53 (3): 293-298.
Richie TL, Saul A: Progress and challenges for malaria vaccines. Nature. 2002, 415 (6872): 694-701. 10.1038/415694a.
Meeusen EN, Snibson KJ, Hirst SJ, Bischof RJ: Sheep as a model species for the study and treatment of human asthma and other respiratory diseases. Drug Discov Today: Dis Models. 2009, 6 (4): 101-106. 10.1016/j.ddmod.2009.12.002.
Barnes P: New treatments for chronic obstructive pulmonary disease. Curr Opin Pharmacol. 2001, 1: 217-222. 10.1016/S1471-4892(01)00039-X.
Renne RA, Wehner AP, Greenspan BJ, Deford HS, Ragan HA, Westerberg RB, Buschbom RL, Burger GT, Hayes AW, Suber RL: Mosberg AT: 2-week and 13-week inhalation studies of aerosolized glycerol in rats. Inhal Toxicol: Int Forum Respir Res. 1992, 4 (2): 95-111. 10.3109/08958379209145307.
Klinman DM, Klaschik S, Tross D, Shirota H, Steinhagen F: FDA guidance on prophylactic DNA vaccines: analysis and recommendations. Vaccine. 2010, 28 (16): 2801-2805. 10.1016/j.vaccine.2009.11.025.
Cai Y, Rodriguez S, Hebel H: DNA vaccine manufacture: scale and quality. Expert Rev Vaccines. 2009, 8 (9): 1277-91. 10.1586/erv.09.84.
Lengsfeld C, Anchordoquy T: Shear-induced degradation of plasmid DNA. J Pharm Sci. 2002, 91 (7): 1581-1589. 10.1002/jps.10140.
Kleemann E, Dailey L, Abdelhady H, Gessler T, Schmehl T, Roberts C, Davies M, Seeger W, Kissel T: Modified polyethylenimines as non-viral gene delivery systems for aerosol gene therapy: investigations of the complex structure and stability during air-jet and ultrasonic nebulization. J Control Release. 2004, 100 (3): 437-450. 10.1016/j.jconrel.2004.09.005.
Levy M, Collins I, Yim S, Ward J, Titchener-Hooker N, Ayazi Shamlou P, Dunnill P: Effect of shear on plasmid DNA in solution. Bioprocess Biosyst Eng. 1999, 20 (1): 7-13. 10.1007/s004490050552.
Hsieh CC, Balducci A, Doyle PS: An experimental study of DNA rotational relaxation time in nanoslits. Macromolecules. 2007, 40 (14): 5196-5205. 10.1021/ma070570k.
Lentz YK, Anchordoquy TJ, Lengsfeld CS: Rationale for the selection of an aerosol delivery system for gene delivery. J Aerosol Med. 2006, 19 (3): 372-384. 10.1089/jam.2006.19.372.
Köping-Höggård M: A miniaturized nebulization catheter for improved gene delivery to the mouse lung. J Gene Med. 2005, 7 (9): 1215-1222. 10.1002/jgm.762.
Torrieri-Dramard L, Lambrecht B, Ferreira H. L, Van den Berg T, Klatzmann D, Bellier B: Intranasal DNA vaccination induces potent mucosal and systemic immune responses and cross-protective immunity against influenza viruses. Mol Ther. 2010, 19 (3): 602-611.
Wee J, Scheerlinck JPY, Snibson K, Edwards S, Pearse M, Quinn C, Sutton P: Pulmonary delivery of ISCOMATRIX influenza vaccine induces both systemic and mucosal immunity with antigen dose sparing. Mucosal Immunol. 2008, 1 (6): 489-496. 10.1038/mi.2008.59.
Babihk LA, Pontarollo R, Babiuk S, Loehr B: van Drunen Littel-van den Hurk S: Induction of immune responses by DNA vaccines in large animals. Vaccine. 2003, 21 (1): 649-658.
Shedlock DJ, Weiner DB: DNA vaccination: antigen presentation and the induction of immunity. J Leukoc Biol. 2000, 68 (6): 793-806.
McLachlan G, Davidson H, Holder E, Davies LA, Pringle IA, Sumner-Jones SG, Baker A, Tennant P, Gordon C, Vrettou C, Blundell R, Hyndman L, Stevenson B, Wilson A, Doherty A, Shaw DJ, Coles RL, Painter H, Cheng SH, Scheule RK, Davies JC, Innes JA, Hyde SC, Griesenbach U, Alton EW, Boyd AC, Porteous DJ, Gill DR, Collie DD: Pre-clinical evaluation of three non-viral gene transfer agents for cystic fibrosis after aerosol delivery to the ovine lung. Gene Ther. 2011, 18 (10): 996-1005. 10.1038/gt.2011.55.
Funding for this work was provided through Australian Research Council (ARC) Discovery Project Grants DP2433214, DP120100013, and DP120100835, and National Health & Medical Research Council (NHMRC) Development Grants 546238 and 1000513. AR was supported by an Australian Postgraduate Award (APA) scholarship. LY is grateful to the ARC for an Australian Research Fellowship under ARC Discovery Project Grant DP0985253. JF is grateful to the Melbourne Centre for Nanofabrication (a node of the Australian National Fabrication Facility) for a Senior Tech Fellowship and to RMIT University for the Vice-Chancellor’s Senior Research Fellowship that in part supported this work. The authors wish to thank Ian Barr for extremely helpful discussions. The authors gratefully acknowledge the technical support of Charles Ma, Hamish McWilliam, Gary Nguyen, Shalini Yapa, Sumay Ng, Adam Mechler, Peggy Chan, Mats Bjorkland, and John Haynes.
The authors declare that they have no competing interests.
JF and LY designed and developed the nebulizer technology, designed the experiments with EM and RC, and supervised the work. AR, JH, and AQ conducted the experiments, compiled the results, conducted the statistical analysis, and wrote the initial drafts of the manuscript. AR, AQ, RB, LY, RC and JF wrote the final draft of the manuscript. MP, THN, DP and EM aided with the rat and mouse model experiments. DP, RB and EM also aided with the sheep model experiments, and RC provided pDNA samples and provided input to AR, JH and AQ on their analysis of the pDNA. All authors read and approved the final manuscript.
Authors’ original submitted files for images
Below are the links to the authors’ original submitted files for images.
About this article
Cite this article
Rajapaksa, A.E., Ho, J.J., Qi, A. et al. Effective pulmonary delivery of an aerosolized plasmid DNA vaccine via surface acoustic wave nebulization. Respir Res 15, 60 (2014) doi:10.1186/1465-9921-15-60
- Gene therapy
- Surface acoustic wave